Frymaster TB14 Manuel d'utilisateur

PARTS LISTINCLUDEDFrymaster, a member of the Commercial Food Equipment Service Association, recommendsusing CFESA Certified Technicians.Price: $10.00

TB14 SERIES GAS FRYERSCHAPTER 2: IMPORTANT INFORMATION2-22.4 Pre-Installation (cont.)2. Frymaster TB14 Series gas fryers require 120VAC 60 cycle or

TB14 SERIES GAS FRYERSCHAPTER 2: IMPORTANT INFORMATION2-32.4 Pre-Installation (cont.)3. CE/EXPORT STANDARDS: Fryer installation must conform with l

TB14 SERIES GAS FRYERSCHAPTER 2: IMPORTANT INFORMATION2-42.7 Receiving and Unpacking EquipmentA. Check that the container is upright. Use an outwar

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-13.1 Installing the FryerA. Initial Installation: If the fryer is installed with legs, do not push t

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-23.3 Installing Casters and LegsA. Install casters and/or legs near where the fryer is to be used, a

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-33.4 Gas Connections DANGERBefore connecting new pipe to this appliance the pipe must be blown out th

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-43.4 Gas Connections (cont.) DANGERAll connections must be sealed with a joint compound suitable for

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-53.4 Gas Connections (cont.)E. Manifold Pressure: Only qualified personnel should check the manifold

TB14 SERIES GAS FRYERSCHAPTER 3: INSTALLATION3-63.4 Gas Connections (cont.)3. If disconnection of the restraint is necessary, this restraint must b

TB14 SERIES GAS FRYERSCHAPTER 4: FRYER OPERATIONS4-14.1 Initial Start-up WARNINGThe on-site supervisor is responsible for ensuring that operators ar

Please read all sections of this manual and retain for future reference. NOTICE This appliance is intended for professional use only and is to be op

TB14 SERIES GAS FRYERSCHAPTER 4: FRYER OPERATIONS4-24.1.1 Pilot Lighting Procedures, Standing Pilot Only (cont.)The inlet pipe at the lower rear of

TB14 SERIES GAS FRYERSCHAPTER 4: FRYER OPERATIONS4-34.2 Boil-Out Procedure DANGERNever leave the fryer unattended during the boil-out process. If t

TB14 SERIES GAS FRYERSCHAPTER 4: FRYER OPERATIONS4-44.2 Boil-Out Procedure (cont.)8. Close the drain, add fresh water (without boil-out solution) a

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-1 WARNINGDrawings and photos used in this manual are intended to illustrate operational,cleanin

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-25.1 GeneralFrymaster TB14 Series gas fryers come equipped with a built-in filtration system.

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-35.2 Filtration PreparationOn initial installation and before each use, remove all loose parts

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-45.2.1 Assembling the Filter (cont.)Assemble the filter as follows:1. Place the support grid

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-55.2.1 Assembling the Filter (cont.)4. Sprinkle 8 ounces of filter powder on thefilter sheet.

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-65.2.2 Installing the FilterSlide the filter inside the fryer cabinet. Ensurethe male-female

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-75.3.2 Filtering ToolsAssemble tools to be used for filtering. These are supplied with the fi

DANGERAdequate means must be provided to limit the movement of this appliance without dependingupon the gas line connection. Single fryers equipped

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-85.4 Operating the Filter (cont.) DANGERDo not drain more than one frypot at a time into the b

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-95.4.2 Filter Operation CAUTIONNEVER operate the filter unit unless cooking oil/shortening is

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-105.4.2 Filter Operation (cont.)4. After ensuring the filter pan is correctlypositioned under

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-115.4.2 Filter Operation (cont.)6. Oil will begin to pump from the filter paninto the frypot.

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-125.4.2 Filter Operation (cont.)9. After all oil is pumped back into the frypot,bubbles will

TB14 SERIES GAS FRYERSCHAPTER 5: BUILT-IN FILTRATION5-135.4.2 Filter Operation (cont.)12. Do not allow crumbs to accumulate in thecrumb tray. The c

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–16.1 Operating Fryers with Computer Magic III.5 Computers12453867ITEM DESCRIPTION1 Lighted Disp

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–26.1.1 Equipment Setup and Shutdown ProceduresSetup WARNINGFill the frypot to the bottom OIL LE

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–36.1.1 Equipment Setup and Shutdown Procedures (cont.)d. " " indicating that the fry

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–46.1.1 Equipment Setup and Shutdown Procedures (cont.)5. At this time, the hold time will be d

TB14 Series Gas FryersInstallation & Operation ManualTABLE OF CONTENTS Page #1. INTRODUCTION

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–56.2 Programming the Computer Magic III.5 Computer (cont.)Sensitivity adjusts computer-cooking

TB14 SERIES GAS FRYERSCHAPTER 6: COMPUTER OPERATION6–66.2.1 Boil Feature (cont.)2. To program computer for boil feature, press either switch.3. Pr

TB14 SERIES GAS FRYERSCHAPTER 7: PREVENTATIVE MAINTENANCE7-17.1 General DANGERNever attempt to clean the fryer during the cooking process or when th

TB14 SERIES GAS FRYERSCHAPTER 7: PREVENTATIVE MAINTENANCE7-27.4 Periodic/AnnualThis appliance should be inspected and adjusted periodically by quali

TB14 SERIES GAS FRYERSCHAPTER 7: PREVENTATIVE MAINTENANCE7-37.4 Periodic/Annual (cont.)Built-in Filtration (cont.):• Check filtration system integr

TB14 SERIES GAS FRYERSCHAPTER 8: TROUBLESHOOTING8-18.1 General DANGERHot cooking oil/shortening will cause severe burns. Never attempt to move this

TB14 SERIES GAS FRYERSCHAPTER 8: TROUBLESHOOTING8-28.2 Pilot Burner Malfunction (cont.)4. Check all connections for cleanliness and security.C. Pi

TB14 SERIES GAS FRYERSCHAPTER 8: TROUBLESHOOTING8-38.3 Main Burner Malfunctions (cont.)D. Fryer will not reach the temperature setting and/or runs

TB14 SERIES GAS FRYERSCHAPTER 8: TROUBLESHOOTING8-48.4 Wiring Diagrams8.4.1 TB14 Series With Built-In Filtration13BOARD 8073651COMPUTER INTERFACEBL

TB14 SERIES GAS FRYERSCHAPTER 8: TROUBLESHOOTING8-58.4.2 TB14 Series Interface Board (Enlarged View)RIGHTTEMPPROBE4J387R-HEATLED 4RL-3R-GVLED 5RPWRV

TB14 Series Gas FryersInstallation & Operation ManualTABLE OF CONTENTS (CONT.) Page #5. BUILT-IN FILTRATION

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-19.1 Accessories1 234 5ITEM PART # COMPONENT1 803-0022 Basket, Fry – TB142 803-0277 Grid Assembly, Fryp

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-29.2 Cabinetry and Related Components123456789101112131415 1617181920

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-39.2 Cabinetry and Related Components (cont.)ITEM PART # COMPONENT1 823-3248Support, Leg- Without Optio

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-49.3 Computer and Related Components1 2 345 6 78910ITEM PART # COMPONENT1 210-3562 Panel, Control- TB14

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-59.4 Filter Module ComponentsTo FrypotTo Filter12345678910111213141517 161819192020 2122 23242526282729

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-69.4 Filter Module Components (cont.)ITEM PART # COMPONENT12 807-3620 Switch, Toggle13 807-3795 Mount,

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-79.5 Filter Pan Components123456789 1011 12ITEM PART # COMPONENT1 106-2257SP Pan Assembly, Filter- SUFF

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-89.6 Frypot, Burners and Related Components363738125262728293031323433351415172022241618192321257891011

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-99.6 Frypot, Burners and Related Components (cont.)ITEM PART # COMPONENT1 826-1871 Frypot, SS- 1-¼"

TB14 SERIES GAS FRYERSCHAPTER 9: PARTS LIST9-109.7 Oil Return Components56791011121312348ITEM PART # COMPONENT1 823-3531 Handle, Oil Return2 809-084

TB14 SERIES GAS FRYERSCHAPTER 1: INTRODUCTION1-11.1 After PurchaseIn order to improve service, have the following chart filled in by the Frymaster A

Frymaster, L.L.C., 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106T

TB14 SERIES GAS FRYERSCHAPTER 1: INTRODUCTION1-21.4 Computer Information (cont.)The user is cautioned that any changes or modifications not expressl

TB14 SERIES GAS FRYERSCHAPTER 1: INTRODUCTION1-31.6.1 Definitions (cont.)B. Qualified Installation Personnel1. Qualified/authorized personnel are

TB14 SERIES GAS FRYERSCHAPTER 2: IMPORTANT INFORMATION2-12.1 Product DescriptionFrymaster TB14 Series gas fryers are energy-efficient, tube-style, g