Frymaster YFPRE1817E Manuel d'utilisateur

Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour Service Hotline 1

2-3 2.2 Power Requirements Three (3) Phase Requirements MODEL VOLTAGE WIRE SERVICEMINIMUM WIRE SIZE AWG (mm) AMPS (per leg) YFPRE1817E 208

2-4 DANGER Hot oil can cause severe burns. Avoid contact. Under all circumstances, oil must be removed from the fryer before attempting to move it t

3–1 YFPRE18E ELECTRIC FRYER CHAPTER 3: OPERATING INSTRUCTIONS FINDING YOUR WAY AROUND THE YFPRE18E ELECTRIC FRYER TYPICAL CONFIGURATION

3–2 3.1 Equipment Setup and Shutdown Procedures Setup DANGER Never operate the appliance with an empty frypot. The frypot must be filled to the

3–3 3.2 Controllers This fryer will be equipped the following YUM Wingstreet controller: CAUTION If this is the first time the fryer is being u

3–4

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-1 WARNING Drawings and photos used in this manual are intended to illustrate operationa

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-2 4. 1 General Frymaster YFPRE18E fryers come equipped with a built-in filtration system

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-3 4.2.1 Assembling the Filter (cont.) Assemble the filter as follows: 1. Place the sup

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-4 4.2.2 Installing the Filter Slide the filter inside the fryer cabinet. Ensure the mal

NOTICE IF, DURING THE WARRANTY PERIOD, THE CUSTOMER USES A PART FOR THIS ENODIS EQUIPMENT OTHER THAN AN UNMODIFIED NEW OR RECYCLED PART PURCHASED DIRE

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-5 4.3.2 Filtering Tools Assemble tools to be used for filtering. These are supplied wit

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-6 DANGER When draining oil into a disposal unit or portable filter unit, do not fill abov

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-7 4.4.2 Filter Operation (cont.) 5. After ensuring the filter pan is correctly positi

YFPRE18E ELECTRIC FRYER CHAPTER 4: BUILT-IN FILTRATION 4-8 Empty the filter pan crumb tray into a fire-proof container at the end of frying operati

5–1 YFPRE18E ELECTRIC FRYER CHAPTER 5: PREVENTATIVE MAINTENANCE 5.1 Cleaning the Fryer DANGER Never attempt to clean the fryer during the frying

5–2 5.1.3 Clean the Frypot and Heating Elements- Weekly DANGER Never operate the appliance with an empty frypot. The frypot must be filled to the

5-3 5.2.2 Built-In Filtration System DANGER The crumb tray in fryers equipped with a filter system must be emptied into a fireproof container at th

6-1 YFPRE18E ELECTRIC FRYER CHAPTER 6: OPERATOR TROUBLESHOOTING 6.1 Introduction This section provides an easy reference guide to some of the comm

6-2 6.2 Troubleshooting 6.2.1 Controller and Heating Problems Problem Probable Causes Corrective Action A. Power cord is not plugged in or circ

6-3 Problem Probable Causes Corrective Action Fryer repeatedly cycles on and off when first started. Fryer is in melt-cycle mode. This is normal beh

DANGER The front ledge of this appliance is not a step! Do not stand on the appliance. Serious injury can result from slips or contact with the ho

6-4 Problem Probable Causes Corrective Action Filter pump runs but oil does not return to frypot and there is no bubbling oil. Blockage in filter pa

THIS PAGE INTENTIONALLY LEFT BLANK

Frymaster, L.L.C., 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-688-2200 (Tech Support) 1-318-219-7135 819-

i YFPRE18E Electric Fryer Installation and Operation Manual TABLE OF CONTENTS CHAPTER 1: Introduction 1.1 General Information...

1-1 YFPRE18E ELECTRIC FRYERS CHAPTER 1: INTRODUCTION 1.1 General Read the instructions in this manual thoroughly before attempting to operate this

1-2 the equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at

1-3 1.6 Shipping Damage Claim Procedure What to do if your equipment arrives damaged: Please note that this equipment was carefully inspected and

2-1 YFPRE18E ELECTRIC FRYER CHAPTER 2: INSTALLATION INSTRUCTIONS 2.1 General Proper installation is essential for the safe, efficient, trouble-fre

2-2 DANGER This appliance must be connected to a power supply having the same voltage and phase as specified on the rating plate located on the insi