Frymaster SM80 Manuel d'utilisateur

Price: $8.00 Service Hotline 1-318-865-1711 819-5894MAY 2007 Dean Millivolt Gas Fryers (CE) Installation & Operation Manual Model

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General (cont.) Where conflicts exist between instructions and informatio

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-3 2.4 Rating Plate DANGER Fryers MUST be connected ONLY to the gas-type identif

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) C. Installation Standards 1. CE/EXPORT STANDA

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-5 2.8 Conversion of Units Pressure: 1 mbar = 10,2 mm W.C. = 0,4-inch W.C. 20 m

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-1 3.1 Installing the Fryer A. Initial Installation: If installed with leg

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-2 3.2 Leg and Caster Installation (cont.) B. Leg and Rigid Caster Installa

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-3 3.3 Leveling the Fryer (cont.) Rigid Casters (Only) 1. Install the rigi

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-4 3.3 Leveling the Fryer (cont.) NOTE: The installation must be inspected a

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-5 3.4 Gas Connections (cont.) NATIONAL CODE REQUIREMENTS This equipment is

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-6 3.4 Gas Connections (cont.) DANGER "Dry-firing" your unit will

i Please read all sections of this manual and retain for future reference. NOTICE This appliance is intended for professional use only and is to be

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-7 3.4 Gas Connections (cont.) 3. If a vent line from the gas pressure regu

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-8 3.4 Gas Connections (cont.) WARNING Do not attach accessories to this f

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-9 3.6 Gas Inputs Nominal Heat Inputs (Qn), Gas Type, Orifice Size, Part Num

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-10 3.6 Gas Inputs (cont.) A. Adjustments for different gases are as foll

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-11 3.7 Gas Conversion Procedures DANGER This appliance was configured at t

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-12 3.7 Gas Conversion Procedures (cont.) Conversions can only be executed b

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-13 3.8 Gas Conversion Components Use the following components to convert fr

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-1 4.1 Initial Startup WARNING The on-site supervisor is responsible for ensuring th

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-2 4.1.1 Pilot Lighting Procedures Initial Pilot Lighting: All Dean fryers are tested,

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-3 4.1.1 Pilot Lighting Procedures (cont.) 9. If the pilot does not stay lit, depress

ii DANGER The front ledge of the fryer is not a step. Do not stand on the fryer. Serious injury can result from slips or contact with the hot oil.

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-4 4.2 Boil-Out Procedure (cont.) 6. The burners will heat the boil-out solution to a

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-5 4.3 Final Preparation DANGER Do not go near the area directly over the flue outlet

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-6 4.3.2 Opening: Beginning the Work Day At the beginning of each work day, always che

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 4: FRYER OPERATION 4-7 4.3.3 Filtering Basics (cont.) e When completing a filter cycle, always close the

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 5: PREVENTATIVE MAINTENANCE 5-1 5.1 General DANGER Never attempt to clean the fryer during the cooking

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 5: PREVENTATIVE MAINTENANCE 5-2 5.1.3 Periodic The fryer should be inspected and adjusted periodically by

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 6: TROUBLESHOOTING 6-1 6.1 General DANGER Hot cooking oil/shortening will cause severe burns. Never at

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 6: TROUBLESHOOTING 6-2 6.3 Main Burner Malfunction A. Main burner will not come "ON": no gas de

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 6: TROUBLESHOOTING 6-3 6.4 Millivolt Wiring Diagram (CE) WARNINGDO NOT CONNECT ANY EXTERNALELECTRICAL PO

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 6: TROUBLESHOOTING 6-4 6.5 Recommended Spare Parts Commonly replaced parts in older Dean Millivolt Gas (CE

i Dean Millivolt Gas Fryers (CE) Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 Applicability an

Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-8

ii Dean Millivolt Gas Fryers (CE) Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 4. FRYER OPERATIONS 4-1 4.1 Init

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-1 1.1 Applicability and Validity Dean Super Marathon and Super Runner Series gas model

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-2 1.4 Safety Information Before attempting to operate your unit, read the instructions i

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 1: INTRODUCTION 1-3 1.5.1 Definitions (cont.) B. Qualified Installation Personnel 1. Qualified/authoriz

DEAN MILLIVOLT GAS FRYERS (CE) CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the container is uprigh