Frymaster Portable Filters MF90 Series Manuel d'utilisateur

Dean Industries, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. Price: $6.00 24-Hou

3-2 3.1.1 Filter Paper Configuration (cont.) D. Sprinkle 16 ounces of filter powder on the top filter sheet. Distribute the powder over the filter

4-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 4: FILTER OPERATION 4.1 General The Dean Portable Filters are designed to operate prim

4-2 4.2 Filtering Tools These tools are not required, but are recommended to make the filtering task easier. A. Measuring Cup: Used to measure eig

4-3 4.4 Changing Filter Paper (cont.) Remove and replace the paper as follows: 1. Remove filter cover. 2. Open the locking clips of the hold-dow

4-4 4.4 Changing Filter Paper (cont.) 4. Remove and check the support screen for cleanliness and scrub if necessary. Ensure there is no build-up o

4-5 4.4 Changing Filter Paper (cont.) 7. Replace the hold-down ring and secure. 8. Replace filter pan cover. 4.5 Unit Operation 1. Whe

4-6 4.5 Unit Operation (cont.) 6. Open the fryer door and ensure the filter is in the proper position under the fryer drain valve extension. Lock

4-7 4.5 Unit Operation (cont.) 8. With oil return nozzle in the vessel, turn filter switch “ON” to begin pumping clean oil into the fryer. Allow

4-8 4.5 Unit Operation (cont.) NOTE: After filtering, scrape off debris and sediment accumulated on the filter paper and discard. CAUTION

5-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5.1 General Cleaning operations fall into three general ca

i Please read all sections of this manual and retain for future reference. Installation, maintenance, and repairs should be performed by you

5-2 5.3 Daily- Close Of Business At the close of a working day, the last order of business should be to filter the oil in all fryers. When the last

6-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING 6.1 Operating Problems Plugged lines and plugged filter paper accou

6-2 6.2 Troubleshooting Flowcharts The following flowcharts contain information to assist the user in diagnosing the most common malfunctions with p

6-3 Filter Pump Fails To Pump Oil If filter unit has aheater, turn heaterON and allow toheat for 20minutes.Insert flexible oilreturn hose intofilter

6-4 Rate Of Oil Return Slowing Rate of oil return to fryer is slowing.Is this the first fryer being filteredduring this filtering session?Check the

6-5 Blockage Between Filter Pan and Flex-Hose Valve Disconnect oil line fromfilter pan to pump at thepump end.Pump is clear; plug isin the bottom of

6-6 6.3 Wiring Diagrams MF90 Filter Wiring (AU)OPTIONALSuction SumpHeater One Way ValveHeater7 AMP2 AMPFUSEINDICATORLIGHTTIMERSWITCHOFF/ON HEATER

7-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 7: PARTS LIST 7.1 MF-90/65, U and AU Configuration

7-2 7.1 MF-90/65, U and AU Configuration (cont.) ITEM PART # COMPONENT 1 44272-1 Frame Assembly 2 44-0409 Caster Channel 3 1004 Bolt, ¼ -

7-3 7.1 MF-90/65, U and AU Configuration (cont.) ITEM PART # COMPONENT 38 1036 Nut, ½-inch Flare 37° 39 1037 Tubing Sleeve ½-inch 37° 40 1

ii MF90 Series Portable Filters TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 2. IMPORTANT INFORMATION 2-1 3.

7-4 7.1 MF-90/65, U and AU Configuration (cont.) ITEM PART # COMPONENT 74 44273 Heater Junction Box 75 44561 8" Strip Heater w/Bracket

7-5 7.2 MF-90/80, 80-LP, 110, 126, 160 and 172 Series, U and AU Configurations (cont.) ITEM PART # COMPONENT 1 55084 Lid, Filter Pan Assembly,

7-6 7.2 MF-90/80, 80-LP, 110, 126, 160 and 172 Series, U and AU Configurations (cont.) ITEM PART # COMPONENT 15 55217 Suction Tube, Pan to Filt

7-7 7.2 MF-90/80, 80-LP, 110, 126, 160 and 172 Series, U and AU Configurations (cont.) ITEM PART # COMPONENT * 1061 Union, Black Pipe, ½-inch *

Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-8

1-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1.1 Ordering Parts Customers may order parts directly from their local

1-2 1.3 After Purchase In order to improve service, have the following chart filled in by the Dean Authorized Service Technician who installed this

2-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2.1 General The MF-90 portable oil filters may be used with a

2-2 2.1 General (cont.) The used oil may be drained by gravity from the fryer into the filter pan, or removed from the fryer by use of a suction/r

2-3 2.4 Unpacking the Filter System Ensure the container is upright. Unpack the filter carefully and remove all accessories from the carton. Do no

3-1 DEAN PORTABLE MICRO-FLO OIL FILTRATION SYSTEMS CHAPTER 3: INSTALLATION INSTRUCTIONS 3.1 Assembling The Filter System On initial installation